Crews work to replace and refit a water filter system aboard the MV Puyallup at the Eagle Harbor Maintenance Facility on Bainbridge Island last Thursday. (Kevin Clark/Everett Herald)

Crews work to replace and refit a water filter system aboard the MV Puyallup at the Eagle Harbor Maintenance Facility on Bainbridge Island last Thursday. (Kevin Clark/Everett Herald)

Washington State Ferries plans for an electric-hybrid fleet

Largest system in the nation launches ambitious plan to move toward zero emissions

As the ferry pulls away from the dock, the rumble from the engine grows louder and vibrations rattle passengers on the sun deck.

A quieter, cleaner ride could be on the horizon for people and marine life as Washington State Ferries embarks on an experimental plan to transition the fleet from diesel to electric power.

“It’s new territory. A lot of stuff depends on what we think we can do,” said Mark Nitchman, a chief engineer for state ferries. “But we should espouse what we stand for and lead the way.”

To accomplish this ambitious plan, the agency is starting by converting the three largest ferries in the fleet from diesel to hybrid-electric propulsion. The three Jumbo Mark II boats — the Tacoma, Puyallup and Wenatchee — are the biggest fuel consumers, together burning 14,000 gallons of diesel a day. They usually run on the Seattle-to-Bainbridge and Edmonds-to-Kingston routes.

At the same time, the state has contracted Seattle-based Vigor to build up to five electric-hybrid Olympic class ferries, which the state hopes to put into service from 2022 through 2028. They are smaller than the Jumbo Mark II boats and are estimated to cost between $140 million and $180 million per vessel.

This is all part of Gov. Jay Inslee’s goal of moving toward a zero-emissions fleet. The fleet today is the largest consumer of diesel fuel in the state, using more than 18 million gallons a year, according to the state.

Shaft alley is seen aboard the MV Puyallup at the Eagle Harbor Maintenance Facility on Bainbridge Island last Thursday. (Kevin Clark/Everett Herald)

Shaft alley is seen aboard the MV Puyallup at the Eagle Harbor Maintenance Facility on Bainbridge Island last Thursday. (Kevin Clark/Everett Herald)

Washington State Ferries is leading the way to electric ferries that haul cars and passengers, Nitchman said. And if all goes well, the state could operate the biggest hybrid auto-transporting ferries anywhere in the country.

Replacing the diesel engines in the massive boats with battery packs will be no easy task. Nitchman likens the conversion process to major surgery.

“There’s a lot to learn. We’ve never run a hybrid boat before,” he said. “I’m excited to be diving into this technology.”

Last month, the state selected Siemens, a global company that specializes in power generation, to do the conversion work. Planning work will continue through 2020 with construction likely to begin in 2021.

The plan is to remove two of four diesel engines, which spin a generator to create electricity, and replace them with large battery packs to power the motors. Money from the Volkswagen settlement is paying for a large chunk of converting the first boat, which is estimated to cost about $40 million.

Moving toward this system, boats will not only emit fewer pollutants and consume less fuel but also have fewer parts, saving on labor costs, Nitchman said.

“But there is no free lunch,” he added.

Batteries must be replaced every four to five years, and crews will have to learn a new technology.

Mark Nitchman, a chief engineer for Washington State Ferries, said installing hybrid engines on the vessels would be a great legacy to leave before retiring. (Kevin Clark/Everett Herald)

Mark Nitchman, a chief engineer for Washington State Ferries, said installing hybrid engines on the vessels would be a great legacy to leave before retiring. (Kevin Clark/Everett Herald)

The conversion is the less-complicated portion, said Ian Sterling, state ferries spokesperson. To be able to run an electric fleet, charging stations have to be designed and built, and the state has to coordinate that work with various utilities providers.

Washington State Ferries set a goal in its 2040 long range plan that in 20 years, 22 of 26 boats in the fleet would be plug-in hybrids and most terminals would have charging stations.

Until the charging infrastructure is installed, the remaining diesel engines will charge the batteries. Only one is needed to do this, so running as a hybrid system will still reduce emissions, according to Nitchman.

Once charging stations are up and running, the agency assumes charging times can be limited to about 20 minutes, the time it takes to offload and onload many boats.

That’s when the real savings will be seen.

“There are savings even before shore charging, just not as much,” Sterling said.

As the big boats are being converted, the state also is building new hybrid boats. They will work much the same way as the converted boats with diesel engines powering the batteries. The diesel engines will then be used as a back-up system.

A lot of the details for both projects are still being worked out.

“It will take a long time to be all-electric, but that’s ultimately where we want to be,” Sterling said.

Crews work to replace and refit a water filter system aboard the MV Puyallup at the Eagle Harbor Maintenance Facility on Bainbridge Island last Thursday. (Kevin Clark/Everett Herald)

Crews work to replace and refit a water filter system aboard the MV Puyallup at the Eagle Harbor Maintenance Facility on Bainbridge Island last Thursday. (Kevin Clark/Everett Herald)

More in News

Faern Tait of Port Angeles shows off Valentina, a 10-year-old alpaca, at the 2019 Clallam County Fair. Officials have cancelled the 2020 fair with Clallam County not likely able to host large gatherings by mid-August. Sequim Gazette file photo by Michael Dashiell
Clallam County Fair cancelled for 2020

The livestock displays, rodeo, carnival, scones and more will have to wait… Continue reading

Expect delays along US Highway 101 near Sequim for repairs

Maintenance crews for the Washington State Department of Transportation look to take… Continue reading

State gives Clallam County approval for Phase 2

Washington State Secretary of Health John Wiesman has approved Clallam County’s request… Continue reading

Clallam County approves Phase 2 plan

Clallam County has approved a request to move into the next phase… Continue reading

Sequim High School Class of 2020 scholarship recipients

Congratulations to Sequim High School’s Class of 2020! https://issuu.com/sequimgazette/docs/shs_class_of_2020_scholarship_awards_presentation Click on the… Continue reading

Subdued remembrances on Memorial Day

Deidre Magner, longtime groundskeeper for Sequim View Cemetery, raises the flag at… Continue reading

Habitat Clallam sets summer building class

Habitat for Humanity of Clallam County is hosting a seven-week class designed… Continue reading

Police blotter — May 27, 2020

The weekly police blotter includes incidents that occurred in the City of… Continue reading

Ian Thill stands near his Eagle Scout project last year where he restored a shed and installed a bench in Pioneer Memorial Park. Sequim Gazette file photo by Conor Dowley
Eagle Scout’s bench stolen from Memorial Park

Sequim Police are investigating a missing part of a stone bench from… Continue reading

Most Read